EV services priced honestly
From a ₹199 wiper-fluid refill to a ₹49,999 full battery rebuild — every service has a fixed price and a printed scope. No site-visit guesswork.
Wiper fluid refill
Top up wiper fluid + check spray nozzles.
Door hinge & lock lubrication
Lubricate hinges, latches, central-lock mechanism.
Pollen filter clean
Clean existing pollen filter — half the price of replacement.
Wiper blade replacement
Fresh wipers, both sides.
Underbody wash
Rust-prevention underbody pressure wash.
Tyre puncture repair
Plug or patch repair — your safer option.
Wheel balancing (per wheel)
Dynamic balance — eliminates steering wobble.
Coolant top-up
Quick top-up + leak inspection.
Front bay (frunk) wash
Clean the front compartment — EVs have a 'frunk' or HV bay.
Charging port clean & contact test
Clean port pins, measure resistance, treat for oxidation.
Suspension bushing inspection
Inspect all rubber bushings for wear.
12V auxiliary battery test
Quick load test of the 12V starter/aux battery.
Tyre rotation
Cross-rotate tyres for even wear.
Cabin AC filter replacement
Fresh cabin filter — better AC, less dust.
Steering rack lubrication
Clean & re-grease steering rack ends.
Exterior wash + wax
Foam wash, dry, hand wax.
Ather 450X — charging port clean & test
Clean & verify Ather 450X home-charge inlet.
Brake fluid flush & bleed
Drain old DOT-4 fluid, refill, bleed all calipers.
Charger cable replacement
Replace damaged charging cable (vehicle-side or portable).
Hero Vida V1 — OTA update installation
Force-install latest stable OTA on Vida V1.
Post-monsoon inspection
After-rain audit — corrosion, sealing, electronics.
Ola S1 Pro — headlamp firmware update
Fix headlamp flicker / DRL bug via firmware.
Brake disc skim / resurface
Lathe-skim discs to remove grooves & restore flat surface.
Wheel alignment (4-wheel)
Laser 4-wheel alignment to OEM spec.
EV OBD scan & code clear
Read all stored DTCs and clear after fix.
Coolant flush & refill
Drain, flush, refill battery/motor liquid cooling.
Reduction gearbox oil change
Drain + refill single-speed reducer oil.
Battery cooling system clean
Clean radiator fins, fans, and coolant lines.
CCS2 adapter setup & verification
Pair, test, and commission a CCS2 adapter.
Front brake pad replacement
OEM-spec front brake pads installed.
Rear brake pad replacement
OEM-spec rear brake pads installed.
Interior detailing
Deep clean cabin: seats, carpet, dash, vents.
5,000 km service
First scheduled service — visual + diagnostic checks.
Public charging station fault diagnosis (B2B)
On-site CPO fault triage — AC + DC stations.
Shock absorber replacement (per pair)
Replace front or rear pair of shocks.
12V battery replacement
OEM-spec 12V battery swap with module reset.
TVS iQube — BMS calibration
Recalibrate BMS SoC tracking on TVS iQube.
HV insulation resistance test
Mandatory safety test for high-voltage isolation.
BMS health & firmware audit
Audit BMS firmware version, balancing & fault logs.
Mahindra XUV400 EV — thermal management flush
Coolant flush + thermal loop service for XUV400 EV.
Type-2 connector replacement
Swap damaged or worn vehicle-side Type-2 inlet.
Annual care checkup
Once-a-year full inspection — pack to tyres.
Battery SoH cell-level test
Per-cell State-of-Health scan with printed report.
10,000 km service
Second scheduled service with deeper diagnostics.
Thermal imaging scan
FLIR heat-map of battery, motor, charger under load.
Battery pack thermal flush
Flush coolant loop running through pack.
Tata Nexon EV — BMS firmware update
OEM-spec BMS firmware refresh for Tata Nexon EV.
Tata Tigor EV — charging port replacement
Replace damaged Type-2 / CCS-2 inlet on Tigor EV.
Battery balancing tune
Active rebalance pack to even-out cell drift.
Ola S1 Pro — motor & hyper-mode recalibration
Reverse-engineered motor map recalibration for S1 Pro.
MG ZS EV — BMS cell-balance tune
Active cell-balancing pass for MG ZS EV pack.
Motor performance dyno benchmark
Dynamometer + waveform analysis of traction motor.
20,000 km service
Major service with brake fluid flush + coolant.
Inverter waveform analysis
Oscilloscope-based inverter switching diagnosis.
BYD Atto 3 — Blade battery health audit
Forensic SoH audit of BYD's Blade LFP pack.
Ather 450X — Warp mode performance tuning
Optimise Warp mode peak power on Ather 450X.
Pre-purchase forensic inspection (used EV)
180-point deep audit before you buy a used EV.
OCPP firmware update (CPO chargers)
Update CPO charger firmware to latest OCPP version.
Tyre replacement (single, fitted)
Fitted + balanced — tyre + labour all-in.
Motor bearing replacement
Replace worn motor bearings — cures whining noise.
Home AC charger installation (3.3kW)
Certified install of a 3.3kW AC home charger.
Inverter board component-level repair
Replace failed IGBTs/MOSFETs on inverter PCB.
Battery pack disassembly & inspection
Open the pack, photograph, measure, reseal.
Bajaj Chetak — motor controller replacement
Swap failed VCU on Bajaj Chetak.
Home wallbox 7kW setup
Type-2 7kW wallbox install with load balancing.
Motor controller replacement
Swap failed motor controller / VCU.
DC fast charging retrofit
Add a CCS2 DC port to AC-only EVs (where supported).
V2L (vehicle-to-load) retrofit
Add a 3kW 230V outlet powered by your EV pack.
EV motor rewinding
Full stator rewinding with new copper.
CAN bus reverse-engineering
Decode proprietary CAN protocol — written report.
Battery pack rebuild (full)
Full pack disassembly, weak-cell swap, reseal.
Custom BMS firmware development
Bespoke BMS firmware for fleets / conversions.