Ola S1 X Repair Checklist for Indian Owners

Ola's S1 X targets the budget commuter segment. Cost-cutting in components means a specific fault profile we see often at our workshops.

This guide is built from real Ola S1 X repair cases handled at ev.care's workshops in Delhi (expanding to 30+ Indian cities by 2027). Every step below has been verified by our DIYguru-certified technicians — the same engineers who fix these vehicles for the country's leading EV fleets. If you're stuck on any step, our free 2-hour callback will diagnose it for you.

What this guide covers

• S1 X display dimming in direct sunlight
• Charging port flap loose / falling off
• Battery percentage jumping erratically
• Underseat storage latch jammed
• Horn faint or scratchy

5 common Ola S1 X faults — and how to fix each

1. S1 X display dimming in direct sunlight

Step-by-step fix:

1. X uses a lower-spec LCD vs Pro's TFT — visibility drops above 35°C.
2. Tilt the display slightly down to reduce glare.
3. No software fix; if completely unreadable, an anti-glare film helps (~₹200).

✅ DIY-friendly with patience · 💰 ₹200

If the symptom persists after these steps, book an ev.care technician →

---

2. Charging port flap loose / falling off

Step-by-step fix:

1. Cost-saving in early S1 X units used a thinner hinge.
2. Ola replaces the assembly under warranty — request the Gen-2 charge port flap.

✅ DIY-friendly with patience

If the symptom persists after these steps, book an ev.care technician →

---

3. Battery percentage jumping erratically

Step-by-step fix:

1. BMS recalibration needed.
2. Discharge to 10%, then charge to 100% uninterrupted.
3. Repeat once.
4. Display should stabilise within 2 full cycles.

✅ DIY-friendly with patience

If the symptom persists after these steps, book an ev.care technician →

---

4. Underseat storage latch jammed

Step-by-step fix:

1. Plastic latch wears with use.
2. Spray graphite powder (not oil) on the hinge.
3. If still jammed, replace ₹400 part.

✅ DIY-friendly with patience · 💰 ₹400

If the symptom persists after these steps, book an ev.care technician →

---

5. Horn faint or scratchy

Step-by-step fix:

1. 12V horn fed from a small DC-DC converter that under-supplies on the X variant.
2. Upgrade horn rated for the actual 12V output (~₹350).

✅ DIY-friendly with patience · 💰 ₹350

If the symptom persists after these steps, book an ev.care technician →

---

When DIY isn't enough — book an ev.care technician for your Ola S1 X

If a fault repeats after the steps above, if any dashboard error code is showing, or if you notice any unusual smell, heat, or sound from the battery pack — stop driving. Ola S1 X battery and motor faults compound: a minor BMS imbalance left untreated can kill the whole pack inside 6 months.

ev.care dispatches a DIYguru-certified technician to your location with a 2-hour callback. Diagnostic site visit is a flat ₹399, transparent quoted before any work begins. Common Ola S1 X repairs are covered under our Annual Care Plan.

• Book a Ola S1 X repair → — free 2-hour callback
• Get a Ola S1 X repair cost estimate →
• Annual Care Plan for Ola S1 X →

Ola S1 X troubleshooting — frequently asked questions

Q: S1 X display dimming in direct sunlight?

X uses a lower-spec LCD vs Pro's TFT — visibility drops above 35°C. For a permanent fix, book a certified ev.care technician — most Ola S1 X repairs are covered under our Annual Care Plan, and our executive will confirm the cost on a free 2-hour callback.

Q: Charging port flap loose / falling off?

Cost-saving in early S1 X units used a thinner hinge. For a permanent fix, book a certified ev.care technician — most Ola S1 X repairs are covered under our Annual Care Plan, and our executive will confirm the cost on a free 2-hour callback.

Q: Battery percentage jumping erratically?

BMS recalibration needed. For a permanent fix, book a certified ev.care technician — most Ola S1 X repairs are covered under our Annual Care Plan, and our executive will confirm the cost on a free 2-hour callback.

Q: Underseat storage latch jammed?

Plastic latch wears with use. For a permanent fix, book a certified ev.care technician — most Ola S1 X repairs are covered under our Annual Care Plan, and our executive will confirm the cost on a free 2-hour callback.

Q: Horn faint or scratchy?

12V horn fed from a small DC-DC converter that under-supplies on the X variant. For a permanent fix, book a certified ev.care technician — most Ola S1 X repairs are covered under our Annual Care Plan, and our executive will confirm the cost on a free 2-hour callback.

Q: How quickly can ev.care reach me for a Ola S1 X repair?

Standard SLA is a 2-hour callback within Delhi service zones. Fleet customers on a Fleet Care plan get critical-priority 2-hour on-site dispatch. Outside Delhi, we partner with local DIYguru-certified workshops — call to confirm coverage in your city before booking.

Q: What does an ev.care diagnostic site visit cost?

A flat ₹399 for the diagnostic visit — covers up to 90 minutes of technician time at your location. If you go ahead with the repair, the ₹399 is adjusted against the final bill. No hidden charges, and pricing is confirmed before any work starts.

Q: Are Ola S1 X repairs covered under warranty?

Manufacturer warranty (typically 8 years / 1.6 lakh km on the HV battery, 3 years on the vehicle) covers genuine defects. ev.care handles out-of-warranty repairs and post-warranty annual care. For in-warranty issues we'll flag it on the diagnostic visit so you can route the claim correctly.

---

Last updated by the ev.care Service Team. Pricing varies by city, severity, and parts availability — always confirm on the free callback.